+86 0371 8654 9132

flotation process in a mixed copper ore

Effect of reagent chemistry on flotation of mixed copper ore

The process of flotation is extremely challenging due to interdependence of various operating parameters. Current study focused on the selection of reagent system based on the complex mineralogy of Malanjkhand copper-molybdenite deposit. The Malanjkhand porphyry copper deposit is of mixed type (both copper sulphide and copper oxide minerals ...

Copper Flotation - Mineral Processing & Metallurgy

2016-5-16 · A Copper Flotation Flowsheet. Because the copper in this type of ore usually assays only plus or minus 1% copper, the porphyry copper operations must be relatively large in order to be commercial. The flowsheet in this study illustrates a typical 3,000

Segregation Process of Mixed Sulphide Copper Ore

2016-5-21 · Segregation Process of Mixed Sulphide Copper Ore. Sulphide copper ores are normally concentrated by flotation while the oxide ores undergo hydrometallurgical

Flotation of mixed copper oxide and sulphide minerals

2009-3-1 · Flotation of mixed copper oxide and sulphide minerals with xanthate and hydroxamate collectors. ... SX/EW requires capital expenditure to construct a dedicated plant to process oxide ore. Until recently, flotation of copper oxides would normally have been conducted in distinct campaigns to produce a copper concentrate which may not be saleable ...

(PDF) A Review of the Flotation of Copper Minerals

The increasing complexity of ore deposits, declining ore grades and higher global demand for copper has resulted in increased ore processing by flotation plants around the world.

某氧硫混合型铜矿浮选工艺研究-Experimental research on ...

2020-6-23 · The flotation tests were carried out on a mixed copper ore, combining ore properties and flotation process characteristics. Use principle flowsheet of preferential flotation of copper sulfide ore, then recovery vulcanized copper oxide by the method of flotation. The

Review, Evolution and Optimization of the Kansanshi

2016-6-8 · Over the last six years, the Kansanshi copper/gold mine has continued to process significant quantities of complex transitional mixed ores. The effect of the complex mineralogy on the flotation performance is depicted. Initially, ore treated came predominantly from accumulated stockpiles.

Process mineralogical characterization of Kansanshi

2020-12-8 · Process Mineralogical Characterisation of the Kansanshi Copper Ore, NW Zambia by ... sulphide flotation, mixed flotation and oxide leach, followed by solvent extraction and electro-winning. This study revisits the process mineralogy of the ore using modern mineralogy tools, which for such a large and complex deposit cannot but

1 Froth Flotation – Fundamental Principles

2009-8-27 · Table 1: Grade/recovery performance of a hypothetical copper ore flotation process. Product % Weight % Cu Assay Feed 100 2.09 Concentrate 10 20.0 Tailings 90 0.1 (a) From Table 1, the Ratio of Concentration can be calculated as F/C = 100/10 = 10. If only assays are available, the ratio of concentration equals (20 – 0.1)/(2.09 – 0.1) = 10 ...

Mechanochemical sulfidization of a mixed oxide-sulphide ...

2020-3-1 · Mechanochemical sulfidization of a mixed sulfide/oxide copper ore by co-grinding with sulfur and additives including Mg(NO 3) 2 and Fe(NO 3) 3 salts and iron, aluminum and magnesium powders was investigated for the first time. Also, the influence of sulfidization during the wet-milling process was examined on the separation efficiency and recovery of copper in detail.

Flotation of mixed copper oxide and sulphide minerals

2009-3-1 · Flotation of mixed copper oxide and sulphide minerals with xanthate and hydroxamate collectors. ... SX/EW requires capital expenditure to construct a dedicated plant to process oxide ore. Until recently, flotation of copper oxides would normally have been conducted in distinct campaigns to produce a copper concentrate which may not be saleable ...

Copper Flotation - Elmhurst University

2015-4-10 · Ore Concentration by Froth Flotation. Remember that only 0.67% of the ore is copper. The copper minerals and waste rock are separated at the mill using froth flotation. The copper ore slurry from the grinding mills is mixed with milk of lime

Flotation of mixed oxide sulphide copper-cobalt minerals ...

2019-11-22 · recovered as a by-product of copper. In the DRC, mining operations mainly focus on either the sulphide ore or the oxide ore for which ef-fective metallurgical processes are well-established. However, less is known about processes for copper and cobalt extraction from mixed oxide-sulphide ore (Crundwell et al., 2011). From the perspective of

Effect of Desliming on Flotation Response of Kansanshi ...

The Kansanshi mixed copper sulfide-oxide ore contains significant proportions of fine material manifesting in a variety of processing challenges. This paper presents the work which was carried out to evaluate the efficacy of desliming in improving the flotation response of the ore. Two modes of desliming were investigated, namely; sieving and elutriation after which the deslimed material was ...

v116n6a11 Review, evolution, and optimization of the ...

2016-7-19 · flotation of copper oxide or mixed ores is sulphidization, which was first developed with industrial success on Pb–Zn oxide ores in Review, evolution, and optimization of the treatment of Kansanshi mixed copper ore by C. Ngulube*, C. Chongo*, and F.X. Paquot* .2&,3, Over the last six years, the Kansanshi copper-gold mine has continued to

Review, Evolution and Optimization of the Kansanshi

2016-6-8 · Over the last six years, the Kansanshi copper/gold mine has continued to process significant quantities of complex transitional mixed ores. The effect of the complex mineralogy on the flotation performance is depicted. Initially, ore treated came predominantly from accumulated stockpiles.

AN INVESTIGATION OF COPPER RECOVERY FROM A

2010-1-19 · improvement of sulphide-oxide copper ores processing through the use of mixed collector systems has surged. The flotation of a natural porphyry copper ore with bornite and malachite was investigated via fundamental work with pure minerals and a bench-scale testing regime. The

Mechanochemical sulfidization of a mixed oxide-sulphide ...

2020-3-1 · Mechanochemical sulfidization of a mixed sulfide/oxide copper ore by co-grinding with sulfur and additives including Mg(NO 3) 2 and Fe(NO 3) 3 salts and iron, aluminum and magnesium powders was investigated for the first time. Also, the influence of sulfidization during the wet-milling process was examined on the separation efficiency and recovery of copper in detail.

1 Froth Flotation – Fundamental Principles

2009-8-27 · Table 1: Grade/recovery performance of a hypothetical copper ore flotation process. Product % Weight % Cu Assay Feed 100 2.09 Concentrate 10 20.0 Tailings 90 0.1 (a) From Table 1, the Ratio of Concentration can be calculated as F/C = 100/10 = 10. If only assays are available, the ratio of concentration equals (20 – 0.1)/(2.09 – 0.1) = 10 ...

含银铜硫矿石优先浮选工艺与混合浮选工艺对比试验 ...

Abstract:Based on the research of process mineralogy, a pilot study on the preferential flotation and mixed flotation process of a silver-bearing copper-sulfur ore was carried out.After the condition test, the pharmaceutical system was determined and a small-scale ...

copper flotation - Xinhai

2021-3-26 · The sulphide flotation process is generally adopted in the mixed copper ore beneficiation, which mainly has two kinds: first, separate the copper sulfide minerals first, and then separate the copper oxide minerals after the tailings sulfidation. Second, float the copper oxide and copper sulfide at the same time after the sulphidation.

Copper Flotation - Elmhurst University

2015-4-10 · Ore Concentration by Froth Flotation. Remember that only 0.67% of the ore is copper. The copper minerals and waste rock are separated at the mill using froth flotation. The copper ore slurry from the grinding mills is mixed with milk of lime

(PDF) Flotation of mixed copper oxide and sulphide ...

Copper sulphide ores Flotation collectors From previous flotation investigations of mixed copper oxide and sulphide minerals using xanthate and Mineral processing hydroxamate collectors it was hard to distinguish the impact of the alkyl hydroxamate collector on sul- Alkyl hydroxamates phide recovery as the sulphide and oxide minerals occurred ...

Flotation of mixed copper oxide and sulphide minerals

Sherwood Copper's Minto Mine processes a high grade copper–gold deposit in Yukon, Canada. The ore mined is from a primary copper sulphide deposit with separate additional deposits of copper oxides. In conjunction with Ausmelt Chemicals, Minto is currently investigating options to recover copper oxide and sulphide minerals using flotation by blending their primary sulphide ore with oxide ores.

Flotation of mixed oxide sulphide copper-cobalt minerals ...

2019-11-22 · recovered as a by-product of copper. In the DRC, mining operations mainly focus on either the sulphide ore or the oxide ore for which ef-fective metallurgical processes are well-established. However, less is known about processes for copper and cobalt extraction from mixed oxide-sulphide ore (Crundwell et al., 2011). From the perspective of

A study of the flotation characteristics of a complex ...

2020-12-8 · treats three distinct ore types; oxide, sulphide and mixed. The objective of this study was to investigate the floatability of a complex Kansanshi mixed copper ore comprising sulphide and oxide minerals with a view to achieving an optimal flotation performance in the treatment of the Kansanshi ore body. This required an in-depth

CN103611624B - A kind of flotation-acidleach process ...

The invention provides a kind of flotation-acidleach process integration processing low-grade mixed copper ore.Flotation process comprises three steps, first select new and effective collecting agent MA as Copper sulfide ore collector, direct flotation copper-sulphide ores, cupric oxide ore is reclaimed again respectively by sulfide flotation and direct flotation, select new and effective ...

AN INVESTIGATION OF COPPER RECOVERY FROM A

2010-1-19 · improvement of sulphide-oxide copper ores processing through the use of mixed collector systems has surged. The flotation of a natural porphyry copper ore with bornite and malachite was investigated via fundamental work with pure minerals and a bench-scale testing regime. The

Mining Industry | Copper Sulfide Ore and Flotation Process ...

2019-7-9 · 1 Types of copper sulfide ore (1) Single copper mineral Its ore characteristic is relatively simple, and the only useful component that can be recycled is copper. The gangue minerals are mainly quartz, carbonate and silicate. (2) Copper-sulfur ore Called copper-bearing pyrite. In addition to copper minerals, iron sulfide can be recovered, and the main mineral of sulfur is pyrite.

含银铜硫矿石优先浮选工艺与混合浮选工艺对比试验 ...

Abstract:Based on the research of process mineralogy, a pilot study on the preferential flotation and mixed flotation process of a silver-bearing copper-sulfur ore was carried out.After the condition test, the pharmaceutical system was determined and a small-scale ...