+86 0371 8654 9132

use of glass ceramic waste in concrete

(PDF) Use of glass wastes as fine aggregate in Concrete

The effect of waste glass as fine aggregate in concrete mixes was investigated at nano-level by using atomic force microscopy (AFM) technique.

Use of waste glass in concrete: A review

2018-12-22 · Waste glass is a non- biodegradable material and disposal of waste glass into the land results in the soil pollution. So to avoid these disposable problems waste glass is used as partial replacements of coarse and fine aggregates. Use of waste glass in

(PDF) Glass Waste in Concrete: Effect on Workability and ...

Waste glass could also be used as a concrete aggregate, either as a direct replacement for normal concrete aggregates or as a high-value aggregate in architectural concrete

Literature Review on Different Waste Materials Use in

2018-6-19 · They have concluded that ceramic waste can be effectively replaced partially by cement in concrete. M. Iqbal Malik et al.[8] They have studied on the issues of environmental and economic concern had addressed by the use of waste glass as partial replacement of fine aggregates in concrete. Fine aggregates had replaced by waste glass powder as 10%,

Use of ceramic wastes as aggregates in concrete

The use of ceramic waste, originated from construction sites and industries, as fine and coarse aggregate in concrete presents an effective and sustainable endeavor to environmental problems through the reduction in the degradation of natural resources caused by extraction of natural aggregates and decrease in dumping volume as well.

Waste glass powder as partial replacement of cement for ...

2017-6-1 · Utilization of waste glass in ceramic and brick manufacturing process is discussed in a recent study (Andreola et al., 2016). The properties influence the pozzolanic behavior of waste glass and most pozzolans in concrete, are fineness, chemical composition, and the pore solution present for reaction (Imbabi et al., 2012, Rashad, 2015).

The Use of Recycled Glass in Concrete Technical Bulletin ...

2015-9-30 · The Use of Recycled Glass in Concrete Technical Bulletin 110302 Introduction There are large amounts of recycled glass available for use in concrete, but there have been many notable failures in concretes containing recycled glass due to unusual chemistries that occur when glass is included in a

(PDF) The use of ceramic waste aggregates in concrete: a ...

Ceramic waste can be separated into two categories in accordance with the source of its raw materials. In each category, the fired ceramic waste was classified according to the production process differentiating them by the use of red or white ceramic pastes. However, the use of white paste is more frequent and much higher in volume.

(PDF) Ceramic waste in concrete-A Review - ResearchGate

A coarse aggregate replacement scheme in concrete is investigated with three different waste ceramic tile materials in replacement ratios including 20%, 25%, 35%, 50%, 65%, 75%, 80% and 100%.

(PDF) Re-Use of Ceramic Wastes in Construction

ceramic waste, both in the manufacture of concrete and in pastes and mortars. For example, de Brito et al. (2005) and Correia et al. (2006) reported the use of recycled

A Review Paper on Utilisation of Ceramic Waste in

2016-9-9 · Concrete with Ceramic shows higher results in all tests. T. Sekar (2011) studied on strength characteristics of concrete utilizing waste materials viz: ceramic tiles, ceramic insulator waste and broken glass pieces. Ceramic tiles gave the best results when compared to the other two type of waste. The concrete produced by ceramic tile

Use of waste glass in concrete: A review

2018-12-22 · Waste glass is a non- biodegradable material and disposal of waste glass into the land results in the soil pollution. So to avoid these disposable problems waste glass is used as partial replacements of coarse and fine aggregates. Use of waste glass in

Use of Ceramic Waste as Coarse Aggregate in Concrete

2016-7-20 · Use of Ceramic Waste as Coarse Aggregate in Concrete Ravi Shanker Chourasia1 Jobin Joy2 1Senior highway engineer 2PG Student 1MSV International INC 2Rajiv Gandhi Proudyogiki Vishwavidyalaya, Bhopal Abstract— Concrete is a mixture which is produced by blending adequate proportion of cement, water and aggregate.

(PDF) The use of ceramic waste aggregates in concrete: a ...

Ceramic waste can be separated into two categories in accordance with the source of its raw materials. In each category, the fired ceramic waste was classified according to the production process differentiating them by the use of red or white ceramic pastes. However, the use of white paste is more frequent and much higher in volume.

The Use of Ceramic Tile Waste as Aggregate in Concrete

2017-12-18 · The Use of Ceramic Tile Waste as Aggregate . in Concrete . E. H. Wadie, E. F. Sadek, M. M. Abdel Wahab . Abstract—This paper presents the results of an experimental studyto investigate the potential of using recycled ceramic as aggregate in concrete. The ceramic aggregate used in this study wasrecycled from industrial ceramic tile waste in Egypt.

Concrete with ceramic waste aggregate - ScienceDirect

2005-10-1 · Six ceramic waste coarse aggregate concrete mixes were designed by the volumetric method with different water–cement ratios (0.35, 0.40, 0.45, 0.50, 0.55 and 0.60). Similarly, six more conventional concrete mixes were designed with crushed stone coarse aggregate. The volume of individual ingredients was the same in both the ceramic waste ...

The Use of Recycled Glass in Concrete Technical Bulletin ...

2015-9-30 · The Use of Recycled Glass in Concrete Technical Bulletin 110302 Introduction There are large amounts of recycled glass available for use in concrete, but there have been many notable failures in concretes containing recycled glass due to unusual chemistries that occur when glass is included in a

USE OF CERAMIC WASTES IN STRUCTURALS

2016-2-16 · Concrete with ceramic waste aggregate. Cement & Concrete Composites, vol. 27 (2005), 910-913. ACKNOWLEDGEMENTS The authors would like to thank Maria Isabel Sánchez de Rojas and Moisés Frías Rojas, of the IETcc, for their collaboration, and for providing advice and guidance at all times as well as enabling

Engineering Behaviour of Waste Glass as Aggregates in ...

2014-3-1 · In this study waste glass was used as a coarse aggregate in concrete. This paper investigates experimentally the use of waste glass as a partial replacement for traditional coarse aggregates in concrete. The concrete resulting from the use of these recycled aggregates showed that waste glass is estimated to undergo pozzolanic reactions with cement hydrates, forming secondary calcium silicate ...

A Study on Ceramic Waste Powder

2019-1-24 · cement has been replaced by ceramic waste powder accordingly in the range of 0%, 10%, 20%, 30%, 40%, and 50% by weight for M-40 grade concrete and the compressive strength is calculated . The first source is the ceramics industry, and this waste Keyword -ceramic is classifipowder, compressive strength

Use of waste glass in concrete - The Trustees of Columbia ...

Batalin, "Use of Waste Sheet and Bottle Glass For Making Devitrified Glass Concrete" Glass and Ceramics, pp. 510-513, 1992, no month. Xu et al., "Effectiveness of Mineral Admixtures in Reducing ASR Expansion" Cement and Concrete Research, pp. 1225-1236, 1995, no month. ...

Use of Ceramic Waste as Coarse Aggregate in Concrete

2016-7-20 · Use of Ceramic Waste as Coarse Aggregate in Concrete Ravi Shanker Chourasia1 Jobin Joy2 1Senior highway engineer 2PG Student 1MSV International INC 2Rajiv Gandhi Proudyogiki Vishwavidyalaya, Bhopal Abstract— Concrete is a mixture which is produced by blending adequate proportion of cement, water and aggregate.

Use of Ceramic Waste Powder in Cement Concrete

2015-6-10 · Use of Ceramic Waste Powder in Cement Concrete Hardik Patel Dr. N.K. Arora Department of Structural Engineering Principle Darshan Institute of Engineering And Technology, Rajkot, India Lukhdhirji Engineering Collage, Morbi, India Shraddha R. Vaniya Assistant Professor Department of Structural Engineering

The Use of Recycled Glass in Concrete Technical Bulletin ...

2015-9-30 · The Use of Recycled Glass in Concrete Technical Bulletin 110302 Introduction There are large amounts of recycled glass available for use in concrete, but there have been many notable failures in concretes containing recycled glass due to unusual chemistries that occur when glass is included in a

Research into Concrete Blocks with Waste Glass

2019-2-4 · 40%, and 60% aggregate replacement by waste glass with 0-10 mm particle size were 3%, 8% and 5% as compared with control sample without waste glass but decrease in the compressive strength value was 2% at the 20% replacement. In this study, different from earlier studies on concrete with waste glass it is produced paving blocks with FG and CG. In

Use of waste glass as coarse aggregate in concrete ...

2019-8-1 · Use of waste glass as coarse aggregate in concrete: mechanical properties Lan-lan Yan and Jiong-Feng Liang : Abstract The possibility of using recycled coarse glass aggregates as a substitute for natural crushed stone are relatively limited. ... the relationship between cube compressive strength and flexural strength of coarse glass concrete. ...

PAPER OPEN ACCESS Use of Waste Window Glass as

2019-11-23 · Use of Waste Window Glass as Substitute of Natural Sand in Concrete Production Mohammed Seddik Meddah 1 1 Department of Civil & Architectural Engineering, College of Engineering, Sultan Qaboos University, 123 Al-Khod, Oman [email protected] Abstract. Nowadays, the use of various waste and recycled materials and by-products is very

Engineering Behaviour of Waste Glass as Aggregates in ...

2014-3-1 · In this study waste glass was used as a coarse aggregate in concrete. This paper investigates experimentally the use of waste glass as a partial replacement for traditional coarse aggregates in concrete. The concrete resulting from the use of these recycled aggregates showed that waste glass is estimated to undergo pozzolanic reactions with cement hydrates, forming secondary calcium silicate ...

Use of red ceramic waste as fine aggregate in concretes ...

The growth of construction has contributed to a significant increase in the generation of urban waste. The inadequate disposal of this waste causes several environmental impacts. In this context, the use of urban waste as building materials is a viable and innovative technical alternative, being considered advantageous from a technical, economic and environmental point of view.

Recycling ceramic waste powder and its usage as an ...

2020-10-13 · Using ceramic waste powder (CWP) as an ingredient to partially replace cement in concrete will have a positive and progressive environmental impact in addition will help reserve natural resources. In this study, CWP material will be examined as a supplementary cementing